VWDiesel.net The IDI, TDI, and mTDI source.

Engine Specific Info and Questions => IDI Engine => Topic started by: 89VWdieselGolf on January 03, 2008, 09:20:42 am

Title: N/A diesel hard to start in the cold...
Post by: 89VWdieselGolf on January 03, 2008, 09:20:42 am
I'm baaack, bought another diesel (after my turbo aba was starting to suck up too much gas, 200HP is fun, but 300kms to the tank isnt)

and i know it will be hard to start in the cold, but i'm killing my battery trying to do so, i've let my glow plugs cycle 2-3 times over, but it doesnt do the trick, and they are supposed to be new (i havent checked though) Do you guys have any tricks or add ons to help cold starts?

thanks,
Jeff
Title: N/A diesel hard to start in the cold...
Post by: clbanman on January 03, 2008, 09:26:33 am
My last NA (86 with 325k km) started right up no matter what the temps.  It had recent glow plugs prior to my purchasing it and the cold start lever worked properly.   My current NA (91 with ~200k km on the engine) is much more difficult to start.  I don't have any history on the glow plugs, but I know the cold start is not properly adjusted.
Title: N/A diesel hard to start in the cold...
Post by: 89VWdieselGolf on January 03, 2008, 09:36:31 am
see i've found to start it at about -5*C i have to have the cold start pushed IN, pedal the throttle, then when it fires up pull it out.

if i try to start it with the cold start out, theres no hope in hell... and my first one was never like that, so i guess that may need to be adjusted. :roll:

How do i go about doing that? the idle does rev up though when its pulled up

Jeff
Title: N/A diesel hard to start in the cold...
Post by: Zulfiqar on January 03, 2008, 09:50:59 am
If its hopeless by pulling out the cold start - You have maladjusted pump timing and the idling speed lever is also pushing on the Advance cam.

My car was the same until the time I adjusted the pump timing, now it starts on first key, and puliing out the CSA lever actually helps

Just as precautions, add a ground to the starterbolt itself and the cylinder head, the GPs also require a ground to operate properly.
Title: N/A diesel hard to start in the cold...
Post by: 89VWdieselGolf on January 03, 2008, 11:28:56 am
how do you adjust pump timing for the CSA?
Title: N/A diesel hard to start in the cold...
Post by: burn_your_money on January 03, 2008, 11:34:57 am
Quote from: "89VWdieselGolf"
how do you adjust pump timing for the CSA?


You basically just set the timing with the cold start in the proper position (pushed in I believe)

I like to set my cars at 1.00mm advance.

If you don't know the condition of the timing belt it's easiest to do the belt and glow plugs together because you can just take the pump right off. Makes life a lot easier.